THE POSSIBILITY OF USING ASH AND SLAG WASTE FROM INCINERATION TO  PRODUCE HEAVY CONCRETE

Van L. Tang; Dinh T. Nguyen; Anh C. Hoang; Boris Bulgakov; Olga Aleksandrova

doi:doi:10.62980/2076-0655-2024-225-236

VAK Russia 2.1.5 UDC 691.32 CSCSTI 67.09 Russian Classification of Professions by Education 08.06.01 Russian Library and Bibliographic Classification 383 Russian Trade and Bibliographic Classification 6367

THE POSSIBILITY OF USING ASH AND SLAG WASTE FROM INCINERATION TO PRODUCE HEAVY CONCRETE

Published в Technique and technology of silicates · Volume 31, Issue 3, 2024 · Pages 225–236 · Rubrics: MAIN RUBRIC

DOI 10.62980/2076-0655-2024-225-236 EDN ijfesj

Received: 02.07.2024 Accepted: 30.07.2024 Published: 07.11.2024 Language of publication: RUS

Authors

Van L. Tang ¹ · Dinh T. Nguyen ² · Anh C. Hoang ³ · Boris Bulgakov ⁴ · Olga Aleksandrova ⁵

1 Ha Noi, Vietnam

2 Ha Noi, Vietnam

3 Ha Noi, Vietnam

4 Moscow, Moscow, Russian Federation

5 Mytishchi, Moscow, Russian Federation

ABSTRACT

Under the current trend of construction of incinerator power plants in Vietnam, research aimed at solving the problem of utilization of their ash and slag waste is necessary to create a closed-cycle economy. In addition, mass extraction of natural quartz sand negatively affects the ecological situation in the country. The most realistic way out of this situation is the use of synthetic sand as a fine aggregate. The purpose of this study was to obtain heavy concrete using ash and slag waste from incinerator power plant and artificial sand. The article presents the results of experimental research on the use of ash and slag waste from the Green Star incinerator for heavy concrete. Portland cement type CEM I 42,5 H of “But Son” plant, the synthetic sand obtained by limestone crushing, limestone crushed stone of 5 ÷ 10 mm fraction, fly ash, the finely ground bottom slag, the ceramic powder and water-reducing superplasticizer were used as raw materials for concrete production. The results of research showed the possibility of using up to 20% wt. % of the fly ash and the finely ground bottom ash for the production of the heavy concrete. The received concrete mixture has good workability, its mobility on cone settlement makes from 15 to 20 cm, and com-pressive strength of hardened concrete after 28 days makes more than 40 MPa. The obtained results open wide prospects for the use of ash and slag waste from incinerator in construction in Vietnam.

KEYWORDS

incineration plants ash and slag waste artificial sand concrete mix heavy concrete workability average density water absorption compressive strength

Information

Authors:

1. Ha Noi, Vietnam

2. Ha Noi, Vietnam

3. Ha Noi, Vietnam

4. Moscow, Moscow, Russian Federation

5. Mytishchi, Moscow, Russian Federation

Type:

Article

Pages:

from 225 to 236

Status:

Published

Subject area:

VAK Russia 2.1.5
UDC 691.32
CSCSTI 67.09
Russian Classification of Professions by Education 08.06.01
Russian Library and Bibliographic Classification 383
Russian Trade and Bibliographic Classification 6367

Language:

Russian, English

Keywords:

incineration plants, ash and slag waste, artificial sand, concrete mix, heavy concrete, workability, average density, water absorption, compressive strength

References

1. Nacional'noe sobranie V'etnama (2023). https://quochoi.vn/tintuc/Pages/tin-hoat-dong-cua-quoc-hoi.aspx?ItemID=82916 (na V'etnamskom).

2. Ministerstvo prirodnyh resursov i okruzhayuschey sredy V'etnama (2023). https://monre.gov.vn/Pages/tinh-hinh-phat-sinh-chat-thai-ran-thong-thuong.aspx (na V'etnamskom).

3. Ministerstvo nauki i tehnologiy V'etnama (2024). https://www.most.gov.vn/vn/tin-tuc/20559/cong-nghe-dot-chat-thai-phat-dien-tren-the-gioi-va-tai-viet-nam.aspx (na V'etnamskom).

4. Akcionernoe obschestvo Thien Y Environmental Energy (2023 g.). Svodnyy otchet o proizvodstve Thien Y Environmental Energy Joint Stock Company (Hanoy), operatora elektrostancii po pererabotke othodov v Shokshone, v 2023 godu. (na V'etnam-skom).

5. Elektrostanciya Green Star Waste Power Plant (2023). Proiz-vodstvennyy otchet Green Star Waste Power Plant-GCEP (Bak-nin'), operatora Green Star Waste Power Plant (Greenstar) v 2023 godu. (na V'etnamskom).

6. Le Van Tuan, Nguen Kuok Toan, Resheniya po sodeystviyu is-pol'zovaniyu zoly i shlaka ugol'nyh elektrostanciy v kache-stve stroitel'nyh materialov v tendencii krugovoy ekonomi-ki vo V'etname // Stroitel'nyy zhurnal. Vypusk 10. 2021. S. 176-182. (na V'etnamskom).

7. Elektrostanciya Green Star Waste Power Plant (2024). Otkry-toe pis'mo s pros'boy provesti issledovanie po pererabotke i povtornomu ispol'zovaniyu othodov s elektrostancii Green Star-GCEP Waste Power Plant (Baknin') ot 26 yanvarya 2024 goda. (na V'etnamskom).

8. Vatin N.I., Petrosov D.V., Kalachev A.I., Lahtinen P. Pri-menenie zol i zoloshlakovyh othodov v stroitel'stve // Inzhe-nerno-stroitel'nyy zhurnal. 2011. №4. S. 16-21. EDN: https://elibrary.ru/NVYMZJ

9. Entin E.B., Nefedova L.S., Strzhalkovskaya N.V. Zoly TES - syr'e dlya cementa i betona. Cement i ego primenenie. 2012. №2. S. 40-46. EDN: https://elibrary.ru/OZPSTN

10. Vozmozhnost' ispol'zovaniya zol'nyh ostatkov dlya proiz-vodstva materialov stroitel'nogo naznacheniya vo V'etname / V. L. Tang, B. I. Bulgakov, O. V. Aleksandrova, O. A. Larsen // Vestnik Belgorodskogo gosudarstvennogo tehnologicheskogo universiteta im. V.G. Shuhova. – 2017. – № 6. – S. 6-12. – DOIhttps://doi.org/10.12737/article_5926a059214ca0.89600468. – EDN YQPJGJ.

11. Korovkin M.O., Shesternin A.I., Eroshkina N.A., Ispol'-zovanie droblenogo betonnogo loma v kachestve zapolnitelya dlya samouplotnyayuschegosya betona // Inzhenernyy vestnik Dona. №3. 2015. C. 85-95. (In russ.). EDN: https://elibrary.ru/VHSBIJ

12. Larsen, O. Blended binder based on Portland cement and recy-cled concrete powder / O. Larsen, S. Samchenko, V. Naruts // Mag-azine of Civil Engineering. – 2022. – No. 5(113). – P. 11306. – DOIhttps://doi.org/10.34910/MCE.113.6. – EDN ZLGLFF.

13. Larsen, O. A. Tehnologiya pererabotki betonnogo loma s cel'yu polucheniya samouplotnyayuschegosya betona / O. A. Larsen, V. V. Narut', V. V. Voronin // Stroitel'stvo i rekonstrukciya. – 2020. – № 2(88). – S. 61-66. – DOIhttps://doi.org/10.33979/2073-7416-2020-88-2-61-66. – EDN HTTFQF.

14. Samouplotnyayuschiysya beton s kompensirovannoy usadkoy c ispol'zovaniem materialov iz betonnogo loma / S. V. Samchen-ko, V. V. Voronin, O. A. Larsen, V. V. Narut' // Izvestiya vys-shih uchebnyh zavedeniy. Stroitel'stvo. – 2021. – № 2(746). – S. 71-78. – DOIhttps://doi.org/10.32683/0536-1052-2021-746-2-71-78. – EDN EYNTLL.

15. Zager I.Yu., Yashin'kina A.A., Andronova L.N., Sravni-tel'naya ocenka produktov drobleniya gornyh porod mestorozh-deniy nerudnyh stroitel'nyh materialov Yamalo-Neneckogo AO // Stroitel'nye materialy. №5. 2011. C. 84-86. (In russ.). EDN: https://elibrary.ru/OBHCPP

16. Hoang Hong Van, Ha Zyuy Hieu, Nguen Man' Kuong, Fam Van Thin', Nguen Zuy Hieu, Chyong Thi Kim Suan, Do Chong Toan, Issledovanie vliyaniya iskusstvennogo peska i prirodnoy peschanoy smesi na osnovnye svoystva betona // Nauchnyy zhurnal po arhitekture i stroitel'stvu. 2018. S. 90-94. (na V'etnam-skom).

17. Tong Ton Kien, Tran Hoang Han, Cao Thi Hyong, Issledo-vanie vozmozhnosti ispol'zovaniya izdeliy iz peschanika dlya zameny prirodnogo peska v stroitel'nyh rabotah. Sbornik dokladov Nacional'noy nauchno-tehnicheskoy konferencii «Scheben' zamenyaet prirodnyy pesok - Ekologicheski chistye materialy» // Izd. Stroitel'stvo. 2018. S. 83-91. (na V'etnam-skom).

18. Samchenko, S. V. Svoystva cementnyh kompozitov na osnove izvestnyaka v zavisimosti ot ego granulometricheskogo sostava / S. V. Samchenko, O. V. Aleksandrova, A. Yu. Gurkin // Vestnik MGSU. – 2020. – T. 15, № 7. – S. 999-1006. – DOIhttps://doi.org/10.22227/1997-0935.2020.7.999-1006. – EDN TNMMPP.

19. Samchenko, S. The effect of dispersion of limestone on the properties of cement mortar / S. Samchenko, O. Larsen, A. Gurkin // Materials Today: Proceedings: International Conference on Mod-ern Trends in Manufacturing Technologies and Equipment, IC-MTMTE 2019, Sevastopol, 09–13 sentyabrya 2019 goda. Vol. 19. – Sevastopol: Elsevier Ltd, 2019. – P. 2068-2071. – DOIhttps://doi.org/10.1016/j.matpr.2019.07.076. – EDN RVCDLT.

20. Betony na karbonatnom syr'e dlya suhogo zharkogo klimata / S. V. Samchenko, O. A. Larsen, D. A. N. Al'obaidi [i dr.] // Promyshlennoe i grazhdanskoe stroitel'stvo. – 2022. – № 9. – S. 74-79. – DOIhttps://doi.org/10.33622/0869-7019.2022.09.74-79. – EDN JZTOJO.

21. Concrete Modification for Hot Weather Using Crushed Dolo-mite Stone / S. V. Samchenko, O. A. Larsen, I. V. Kozlova [et al.] // Buildings. – 2023. – Vol. 13, No. 10. – P. 2462. – DOIhttps://doi.org/10.3390/buildings13102462. – EDN MGPLFU.

22. Tang Van Lam, Vu Kim Dien (2020). The possibility of using waste slag from the metallurgical industry in the production of con-struction materials. Science & Technology Magazine, Ministry of Industry and Trade. No. 43. October 2020.

23. T.V. Lam, B. Bulgakov, Y. Bazhenov, O. Aleksandrova, P.N. Anh (2018). Effect of rice husk ash on hydrotechnical concrete be-havior // IOP Conf. Series: Materials Science and Engineering. Vol. 365. 2018. Doihttps://doi.org/10.1088/1757-899X/365/3/032007 EDN: https://elibrary.ru/YBNOTZ

24. Ministerstvo stroitel'stva V'etnama, Tehnicheskie in-strukcii po vyboru betonnyh komponentov vseh tipov" so-glasno Postanovleniyu № 778/1998/QD-BXD ot 5 sentyabrya 1998 g. 60 s. (na V'etnamskom).

25. Vliyanie tonkodispersnyh materialov na samouplotnyae-most' betonnoy smesi / O. A. Larsen, S. V. Samchenko, K. S. Stenechkina, D. G. Alpackiy // Tehnika i tehnologiya silikatov. – 2023. – T. 30, № 3. – S. 217-229. – EDN NFDRFF.

26. Samchenko, S. V. Vliyanie dispersnosti shlakovogo kompo-nenta na svoystva shlakoportlandcementa / S. V. Samchenko, O. V. Zemskova, I. V. Kozlova // Tehnika i tehnologiya silikatov. – 2016. – T. 23, № 2. – S. 19-23. – EDN WAOLWF.

27. Alimov, L. A. Ocenka vliyaniya komponentov betona na formirovanie ego struktury i svoystv / L. A. Alimov, V. V. Voronin, O. A. Larsen // Tehnika i tehnologiya silikatov. – 2020. – T. 27, № 1. – S. 20-24. – EDN KYFYIL.

28. Larsen, O. A. Kriterii ocenki strukturno-tehnologicheskih harakteristik betona / O. A. Larsen, V. V. Voronin, S. V. Samchenko // Tehnika i tehnologiya silikatov. – 2023. – T. 30, № 2. – S. 129-143. – EDN QXSDZK.

THE POSSIBILITY OF USING ASH AND SLAG WASTE FROM INCINERATION TO PRODUCE HEAVY CONCRETE

Confirmation

Регистрация